oil filter Ram 3500 2016 Owner's Manual

MAINTAINING YOUR VEHICLE
CONTENTS
ENGINE COMPARTMENT — 3.6L ..........790
 ENGINE COMPARTMENT — 5.7L ..........791
 ENGINE COMPARTMENT — 6.4L ..........792
 ONBOARD DIAGNOSTIC SYSTEM (OBD II) . . .793
▫ Onboard Diagnostic System (OBD II)
Cybersecurity ....................... .793
▫ Loose Fuel Filler Cap Message ............794
 EMISSIONS INSPECTION AND MAINTENANCE
PROGRAMS ......................... .795
 REPLACEMENT PARTS ..................796 
DEALER SERVICE ..................... .797
 MAINTENANCE PROCEDURES ...........797
▫ Engine Oil ......................... .798
▫ Engine Oil Filter ..................... .802
▫ Engine Air Cleaner Filter ................802
▫ Accessory Drive Belt Inspection ...........806
▫ Maintenance-Free Battery ...............808
▫ Air Conditioner Maintenance .............809
▫ Front Driveshaft Lubrication — 2500/3500
(Four-Wheel Drive Models Only) ..........810
7

ENGINE COMPARTMENT — 3.6L
1 — Air Cleaner Filter
2 — Engine Oil Dipstick
3 — Engine Oil Fill
4 — Brake Fluid Reservoir
5 — Battery6 — Washer Fluid Reservoir
7 — Power Distribution Center (Fuses)
8 — Coolant Pressure Cap
9 — Engine Coolant Reservoir
790 MAINTAINING YOUR VEHICLE

ENGINE COMPARTMENT — 5.7L
1 — Air Cleaner Filter7 — Washer Fluid Reservoir
2 — Automatic Transmission Dipstick (6-Speed Trans Only) 8 — Power Distribution Center (Fuses)
3 — Engine Oil Fill 9 — Power Steering Fluid Reservoir (2500/3500 Models Only)
4 — Engine Oil Dipstick 10 — Coolant Pressure Cap
5 — Brake Fluid Reservoir 11 — Engine Coolant Reservoir
6 — Battery
7
MAINTAINING YOUR VEHICLE 791

ENGINE COMPARTMENT — 6.4L
1 — Coolant Pressure Bottle6 — Battery
2 — Transmission Dipstick 7 — Power Distribution Center (Fuses)
3 — Engine Oil Fill 8 — Washer Solvent
4 — Engine Oil Dipstick 9 — Power Steering Fluid Reservoir
5 — Brake Fluid Reservoir 10 — Air Cleaner Filter
792 MAINTAINING YOUR VEHICLE

Synthetic Engine Oils
You may use synthetic engine oils provided the recom-
mended oil quality requirements are met, and the recom-
mended maintenance intervals for oil and filter changes
are followed.
Synthetic engine oils which do not have both the engine
oil certification mark and the correct SAE viscosity grade
number should not be used.
Disposing Of Used Engine Oil And Oil Filters
Care should be taken in disposing of used engine oil and
oil filters from your vehicle. Used oil and oil filters,
indiscriminately discarded, can present a problem to the
environment. Contact your authorized dealer, service
station or governmental agency for advice on how and
where used oil and oil filters can be safely discarded in
your area.
Engine Oil Filter
The engine oil filter should be replaced with a new filter
at every engine oil change.
Engine Oil Filter Selection
This manufacturer’s engines have a full-flow type oil
filter. Use a filter of this type for replacement. The quality
of replacement filters varies considerably. Only high
quality filters should be used to assure most efficient
service. MOPAR engine oil filters are a high quality oil
filter and are recommended.
Engine Air Cleaner Filter
Refer to the “Maintenance Schedule” in the “Mainte-
nance Schedules” section for the proper maintenance
intervals.
802 MAINTAINING YOUR VEHICLE

FLUID CAPACITIES
U.S.Metric
Fuel (Approximate)
1500 Regular Cab Shortbed/Crew Quad Cab Models 26 Gallons98 Liters
1500 Regular Cab Longbed/Crew Quad Cab Models (Optional) 32 Gallons 121 Liters
2500/3500 Shortbed Models 31 Gallons117 Liters
2500/3500 Longbed Models 32 Gallons121 Liters
Engine Oil With Filter
3.6L Engine (We recommend you use SAE 5W-20, API Certified) 6 Quarts5.6 Liters
5.7L Engines (We recommend you use SAE 5W-20, API Certified) 7 Quarts 6.6 Liters
5.7L Engine (We recommend you use SAE 5W-30, API Certified),
for 2500/3500 trucks operating under a gross combined weight
rating greater than 14,000 lbs (6 350 kg). 7 Quarts
6.6 Liters
6.4L Engines (We recommend you use SAE 0W-40 engine oil
meeting the requirements of FCA Material Standard MS-12633 for
use in all operating temperatures.) 7 Quarts
6.6 Liters
864 MAINTAINING YOUR VEHICLE

ComponentFluid, Lubricant, or Genuine Part
Engine Oil Filter We recommend you use MOPAR brand Engine Oil
Filters.
Spark Plugs We recommend you use MOPAR Spark Plugs.
Fuel Selection – 3.6L Engine 87 Octane, 0-15% Ethanol.
Fuel Selection – 3.6L Flex Fuel (E-85) Engine – If
Equipped 87 Octane, Up To 85% Ethanol.
Fuel Selection – 5.7L/6.4L Engines 89 Octane Recommended - 87 Octane Acceptable, 0-15%
Ethanol.
868 MAINTAINING YOUR VEHICLE

Required Maintenance
Refer to the Maintenance Schedules on the following
pages for required maintenance.
At Every Oil Change Interval As Indicated By OilChange Indicator System:
•Change oil and filter.
• Rotate the tires. Rotate at the first sign of irregu-
lar wear, even if it occurs before the oil indicator
system turns on.
• Inspect battery and clean and tighten terminals as
required.
• Inspect automatic transmission fluid if equipped
with dipstick.
• Inspect brake pads, shoes, rotors, drums, hoses
and park brake.
At Every Oil Change Interval As Indicated By Oil
Change Indicator System:
•Inspect engine cooling system protection and
hoses.
• Inspect exhaust system.
• Inspect engine air cleaner if using in dusty or
off-road conditions.
• Lube the front drive shaft fitting (2500/3500 (4x4)
models only).
876 MAINTENANCE SCHEDULES

Hazard Warning Flasher..................727
Jump Starting ......................... .771
Tow Hooks ........................... .777
Emission Control System Maintenance ..........795
Engine ............................. .791, 792
Air Cleaner .......................... .802
Block Heater ......................... .486
Break-In Recommendations ................117
Compartment ......................... .790
Compartment Identification .........790, 791, 792
Coolant (Antifreeze) .....................866
Exhaust Gas Caution .................119,680
Flooded, Starting ...................... .480
Fuel Requirements ...................675, 864
Jump Starting ......................... .771
Oil .......................... .798, 864, 866
Oil Filler Cap ......................... .801
Oil Filter ............................ .802
Oil Selection ...................... .799, 864Oil Synthetic
......................... .802
Overheating .......................... .727
Engine Oil Viscosity ....................800, 801
Engine Oil Viscosity Chart ...................800
Enhanced Accident Response Feature ............81
Entry System, Illuminated ....................24
Ethanol ............................ .677, 681
Event Data Recorder ........................84
Exhaust Gas Caution ....................119,680
Exhaust System .......................119,816
Exterior Lighting ......................... .171
Exterior Lights .......................... .122
Filters Air Cleaner .......................... .802
Engine Oil ........................ .802, 866
Engine Oil Disposal .....................802
Flashers Turn Signal .....................122, 181, 326
10
INDEX 901

Multi-Function Control Lever.................181
Navigation System (Uconnect GPS) .............212
New Vehicle Break-In Period .................117
Occupant Restraints ........................52
Octane Rating, Gasoline (Fuel) ................675
Off-Pavement Driving (Off-Road) ...........570, 593
Off-Road Driving (Off-Pavement) ...........570, 593
Oil, Engine ......................... .798, 866
Capacity ............................ .864
Change Interval ....................... .799
Dipstick ............................. .798
Disposal ............................. .802
Filter ............................ .802, 866
Filter Disposal ........................ .802
Identification Logo ..................... .800
Pressure Warning Light ................302, 305
Recommendation ....................799, 864 Synthetic
............................ .802
Viscosity ...................... .800, 801, 864
Oil Filter, Change ........................ .802
Oil Filter, Selection ....................... .802
Oil Pressure Light ..................... .302, 305
Onboard Diagnostic System ..................793
Operating Precautions ..................... .793
Operator Manual (Owner’s Manual) .............4
Outside Rearview Mirrors ...................138
Overdrive .......................... .509, 520
Overdrive OFF Switch ..................509, 520
Overhead Console ........................ .215
Overheating, Engine ...................... .727
Owner’s Manual (Operator Manual) ..........4,890
Paint Care ............................. .833
Panic Alarm ..............................29
Parking Brake ........................... .616
ParkSense System, Rear ..................194, 203
10
INDEX 907